当前位置:网站首页 > 操作规程
操作规程

                                     Operation Process of Products                                              


产品操作过程

1. Nuisanceless farm of best quality is applicable for farm plant picking, which should usually be done in the morning. No picking in raining days, after rain, with dew condensate, or under sun shine, or the farm plants may decay, softened or prematured.


1、农作物采摘应选择优质、无污染的农场。在清晨进行采摘,雨天、雨后、露水未干的早晨都不宜采收,也不能在日照下采收。 否则会使农作物腐烂、变软早熟。


2. Concerning quality requirement, full grown fruit and vegetable should be hard, and free from bruise, insect pest, bruise, sunburn or germina. 


2、农作物质量要求成熟的果蔬,必须硬、无擦伤、无虫害、无瘀痕、无晒斑、 无病菌。


3. Farm plants should be classified and packed according to their quality when picking.


3、农作物采摘时按品质进行分级包装。


4. Farm plants should go through precooling for at least 12 to 24 hours immediately after picking according to climate conditions and categories in order to avoid field heating. In case no precooling device is available, pick in the early morning. For difference in temperature at night is basically as effective as pre cooling.


4、农作物采收后依照气候条件与农作物种类,应立即进行至少12至24小时的预冷,以消除田间热。若无预冷设备应在大清早进行采收,利用夜间的温差达到最基本的预冷效果。


5. Farm plant, after washing and cleaning, should be aired and dried before packaging. 


5、农作物若进行了清洗,请在装袋之前晾干。


6. Special fresh-keeping bags should be used according to the types of farm plants.One fresh-keeping bag is only for one kind of plant. No mixing is allowed.


6、根据农作物的种类不同,须使用专用保鲜袋。且一个保鲜袋中只能存放一种农作物,不能混装.。


7. Farm plants of suitable weight are put in the bag according to the feature and capability of the PBI active fresh-keeping bag. Weight of fruits and vegetable should be adapted to the bag. It should not exceed the design capacity, or less than 80% of the designed.(eg.: 5kg bag should not be filled with more than 5kg of fruits and vegetables. The bag should be filled with 4kg fruits and vegetables at least) in this way, the best fresh-keeping effect is achieved.



7、依照 PBI物理活化保鲜袋特性和容量,放入适当重量的农作物。果蔬重量必须与袋子匹配,既不可超过设计容量也不可少于80%的设计容量。(例如5 公斤的袋子不可放入超过5 公斤的果蔬,但至少也要装上4 公斤以上的果蔬)这样是最佳保鲜效果。


8. The application of PBI active fresh-keeping bag is very easy. Slowly press the bag and drain the air inside (not evacuation of course) before packaging, furl the bag, and seal with sealing machine, clamp or by making a slipknot, etc.


8、 PBI物理活化保鲜袋的使用非常简易,包装之前缓缓压袋,将空气排出(非抽真空),收拢袋口,可用封口机、夹子、打活结等方式封口。


9. Plant in bag should not be insolated under sunshine. Plants should be stored or shipped according to the most ideal temperature for fruit and vegetable storage. In case no freezing facility is available, shipment should be done at night (of course it is more

       effective if refrigerator car is used for shipment).


9、入袋后的农作物不要直接暴晒在阳光下,应立即按照果蔬的最佳储存温度贮存或运输。运输时若没有冷藏设施的车辆,一般应在夜间进行运输(冷藏车运输保鲜效果更佳)。


10. Gently put plants in bag to avoid booboo. Care should be taken not to damage the packaging box when loading the car, or the fresh-keeping bag in the box may be broken, which possibly result in a poor fresh-keeping.


10、将农作物轻拿轻放入袋,以避免碰伤,装车时不要把外包装箱损坏,防止箱内保鲜袋破裂,影响保鲜效果。

 

 

 

西安披必爱活化保鲜科技有限责任公司


联系方式

电话:029-88441571  029-88441573  18189212687(李经理)

传真:029-88441572    QQ:501802727

邮箱:pbi_china@vip.163.com

网址:www.pbichina.com

地址:西安市高新区科技路70号梧桐朗座B-2204

在线客服
返回顶部